K-WANG

+086-15305925923
Service expert in industrial control field！
English 简体中文
Product
Article
NameDescriptionContent
Adequate Inventory, Timely Service
pursuit of excellence 
Ship control system
Equipment control system
Power monitoring system
Current position:
Home >> ABB >> ABB 3HNA025019-001 Process I/O Controller
新闻动态
newS
   
Brand

ABB 3HNA025019-001 Process I/O Controller

From: | Author:Wang | Time :2024-11-22 | 154 visit: | 🔊 Click to read aloud ❚❚ ▶ | Share:

ABB 3HNA025019-001 Process I/O Controller

Regulatory compliance
The converter module and enclosed converter components are designed for use in industrial environments. In
EEA countries, the components fulfil the requirements of the EU directives, see table below:
Effect of site elevation and ambient temperature on the converter‘s load capacity
Current reduction to % of nominal converter current
Short Circuit Current Ratio (SCCR)
For drives with thyristor modules (H1 ... H5) the SCCR = 65 kA.
For drives with disk type thyristors (H6 ... H8) the SCCR = 100 kA.
European Union Directive Manufacturer's Assurance Harmonized Standards
Converter module
Machinery Directive
2006/42/EC Declaration of Incorporation [IEC 60204-1]
Low Voltage Directive
2014/35/EU Declaration of Conformity EN 61800-1
[IEC 61800-1]
EN 60204-1
[IEC 60204-1]
EN 61800-5-1
[IEC 61800-5-1]
EMC Directive
2014/30/EU Declaration of Conformity
(If all installation instructions concerning
cable selection, cabling and EMC filters or
dedicated transformer are followed.)
EN 61800-3
[IEC 61800-3]
in accordance with 3ADW000032


Current ratings - IEC regenerative converters (S02)
See the current ratings including several standard duty cycles for the DCS880 with 50 Hz and 60 Hz supplies
below. The current ratings are based on an ambient temperature of maximum 40°C and an elevation of
maximum 1000 m above mean sea level:
This unit type can be used as large field exciter. Do not forget the SDCS-DSL-H10 (+S521).
A 10 % current de-rating is strongly recommended.
1190 ADC for 35°C and 1140 ADC for 40°C ambient temperature.
As option.
Notes:
AC current IAC = 0.82 * IDC.
The ratings apply at ambient temperature of 40°C (104°F). For lower temperatures the H6, H7, H8 ratings are
higher (except Imax). Use DriveSize for detailed dimensioning in case the ambient temperature is below 40°C
(104°F) or the drive is loaded cyclically.
Unit type IDC I IDC II IDC III IDC IV Size Internal field current
4-Q converters continuous
100 %
15 min
150 %
60 s
100 %
15 min
150 %
120 s
100 %
15 min
200 %
10 s
400 V / 500 V (IEC) / 525 V (UL) [A] [A] [A] [A]
DCS880-S02-0025-04/05 25 22 33 21 31 20 40 H1 0.3 ... 6 A
DCS880-S02-0050-04/05 50 38 57 37 55 33 66 1 ... 12 A
DCS880-S02-0075-04/05 75 60 90 59 88 54 108
DCS880-S02-0100-04/05 100 85 127 83 124 80 160
DCS880-S02-0150-04/05 150 114 171 110 165 100 200 H2 1 ... 18 A
DCS880-S02-0200-04/05 200 145 217 140 210 115 230
DCS880-S02-0250-04/05 250 185 277 180 270 165 330
DCS880-S02-0300-04/05 300 225 337 220 330 200 400
DCS880-S02-0350-04/05 350 275 412 265 397 245 490 H3 2 ... 25 A
DCS880-S02-0450-04/05 450 350 525 340 510 310 620
DCS880-S02-0520-04/05 520 400 600 380 570 350 700
DCS880-S02-0680-04/05 680 525 787 510 765 475 950 H4 2 ... 30 A
DCS880-S02-0820-04/05 820 630 945 610 915 565 1130
DCS880-S02-1000-04/05 1000 750 1125 725 1087 660 1320
DCS880-S02-1190-04/05 1190  860 1290 835 1253 745 1490 H5 25 A 
+S164 DCS880-S02-1200-04/05 1200 888 1332 872 1308 764 1528 H6
DCS880-S02-1500-04/05 1500 1200 1800 1156 1734 1104 2208
DCS880-S02-2000-04/05 2000 1479 2219 1421 2132 1361 2722
DCS880-S02-2050-05 2050 1550 2325 1480 2220 1450 2900 H7 -
DCS880-S02-2500-04/05 2500 2000 3000 1930 2895 1790 3580
DCS880-S02-3000-04/05 3000 2330 3495 2250 3375 2080 4160
DCS880-S02-3300-04/05 3300 2416 3624 2300 3450 2277 4554 H8 -
DCS880-S02-4000-04/05 4000 2977 4466 2855 4283 2795 5590
DCS880-S02-5200-04/05 5200 3800 5700 3669 5504 3733 7466
600 V / 690 V
DCS880-S02-0320-06 320 256 384 246 369 235 470 H3 -
DCS880-S02-0650-06 650 514 771 508 762 462 924 H4 -
DCS880-S02-0900-06/07 900 684 1026 670 1005 594 1188 H6 25 A 
+S164 DCS880-S02-1500-06/07 1500 1200 1800 1104 1656 1104 2208
DCS880-S02-2050-06/07 2050 1520 2280 1450 2175 1430 2860 H7 -
DCS880-S02-2500-06/07 2500 1940 2910 1870 2805 1740 3480
DCS880-S02-3000-06/07 3000 2270 3405 2190 3285 2030 4060
DCS880-S02-3300-06/07 3300 2416 3624 2300 3450 2277 4554 H8 -
DCS880-S02-4000-06/07 4000 3036 4554 2900 4350 2950 5900
DCS880-S02-4800-06/07 4800 3734 5601 3608 5412 3700 7400
800 V
DCS880-S02-1900-08 1900 1500 2250 1430 2145 1400 2800 H7 -
DCS880-S02-2500-08 2500 1910 2865 1850 2775 1710 3420
DCS880-S02-3000-08 3000 2250 3375 2160 3240 2000 4000
DCS880-S02-3300-08 3300 2655 3983 2540 3810 2485 4970 H8 -
DCS880-S02-4000-08 4000 3036 4554 2889 4334 2933 5866
DCS880-S02-4800-08 4800 3734 5601 3608 5412 3673 7346
990 V
DCS880-S02-2050-10 2050 1577 2366 1500 2250 1471 2942 H8 -
DCS880-S02-2600-10 2600 2000 3000 1900 2850 1922 3844
DCS880-S02-3300-10 3300 2551 3827 2428 3642 2458 4916
DCS880-S02-4000-10 4000 2975 4463 2878 4317 2918 5836
  • Woodward 8406-121 - EGCP-2 / EGCP - 2 Digital Control REV G
  • Woodward 8440-1019 A - SPM-D10/SPM-D Sync Controller synchronizing system
  • Woodward 5466-318 - MicroNet TMR Kernel P.S Module
  • Woodward 8270-1060 - SPEED CONTROLLER REV.D DYN1-10504-004-0-24 FINAL ASSY
  • Woodward 8440-1884 - EASYGEN-2500-5/P1 Genset Controller Rev. A WITHOUT ACCS
  • Woodward 9907-018 - LOW VOLTAGE 2301A LOAD SHARING AND SPEED CONTROL REV.H
  • Woodward 8440-2028 - DIGITAL I/O EXPANSION MODULE REV. NEW IKD1 IKD1M WITH CD
  • Woodward 5431-640 C - Dual Dynamics 1000 Series Speed Control Module
  • Woodward MFR2S45B/EVC1 - CONTROLLER RL20710
  • Woodward 8237-2600 - TURBINE CONTROL PANEL PROTECH GII, 8200-1302
  • Woodward 9907-838 - LOAD SHARING MODULE REV NEW
  • Woodward 8272-582 - APM MOTOR CONTROL 110-220V AC/DC
  • Woodward 5460-570 - SPEED REFERENCE MODULE
  • Woodward 8440-1041 - CONTROL MODULE
  • Woodward 5466-5026 - MICRONET SIMPLEX HIGH DENSITY ANALOG MODULE
  • Woodward 5441-693 - DIGITAL I/O MODULE
  • Woodward 9905-214 - 701 DIGITAL SPEED CONTROL REV J
  • Woodward 8273-1013 - 2301E-ST LOAD SHARING & SPEED CONTROL REV NEW
  • Woodward 9907-018 - 2301a / 2301A Low Voltage Load Sharing AND Speed Control REV.E
  • Woodward MRU4A0AB - HIGH PROTEC VOLTAGE PROTECTION RELAY REV:Y
  • Woodward DPG 2201-002 - Speed Governor (DPG-2201-002)
  • Woodward DYNT 17200 - MAGNETIC PICKUP SENSOR 3/8 07-16
  • Woodward 8440-2028 - IKD1M Digital I/O Expansion Module REV :NEW
  • Woodward 9907-018 - 2301A Load Sharing & Speed Control Rev: H Low Voltage
  • Woodward 8440-1884 - GENSET CONTROLLER EASYGEN-2500-5/P1 REV: K
  • Woodward 9907-173 - Module Load Sharing 120 Volt REV B
  • Woodward APECS MODEL 4500 - PROGRAMMABLE ENGINE CONTROL
  • Woodward 8406-121 - egcp-2 digital control
  • Woodward 8402-214 - SOGAV105 VALVE (24V) GAS METERING WITH 5852-130 800 N SOLENOID
  • Woodward 8440-1041 G - EXPANSION BOARD IKD1
  • Woodward 8444-1104 - MFR300 MULTI FUNCTION RELAY
  • Woodward LS-5 - Motherboard Synchronization Load Distribution Controller
  • Woodward 5460-571 A - SPEED SENSOR MODULE
  • Woodward 8272-582 - APM Motor Control 100-220V AC/DC
  • Woodward 8440-1614 - GCP-32 Genset Control Package REV:H
  • Woodward NC3116 - SEG GENERATOR CONTROLLLER 16463777
  • Woodward 9907-014 - 2301A SPEED CONTROL REV H
  • Woodward 8272-582 - APM MOTOR CONTROL
  • Woodward 8270-1060 - SPEED CONTROLLER REV.C DYN1-10504-004-0-24 FINAL ASSY
  • Woodward 8444-1074A - lsg / LSG Load Share Gateway Transducer Rev: LSG
  • Woodward 9907-018 - LOW VOLTAGE 2301A LOAD SHARING AND SPEED CONTROL REV.E
  • Woodward 8290-189 - Speed Controller Rev. U
  • Woodward 8290-189 - Speed Controller Rev. V
  • Woodward 8272-583 - APM Motor Control 24vdc
  • Woodward 8404-2006 - Lseries ITB 30m Actuator with Position Control logic
  • Woodward 8516-050 - 2400 RPM CW DRIVE SHAFT ROTATION MOTOR
  • Woodward 9905-016 B - Process Control Unit
  • Woodward 5484-721 - motor
  • Woodward 5501-470D - NETCON CPU_040 W/O LL MEMORY Rev A
  • Woodward 3522-1004 - BUM60-1224-54-B-001 EM- DRIVER BUM60-VC-A0-0093
  • Woodward 9907-019 - LOW VOLTAGE 2301A LOAD SHARING & SPEED CONTROL REV.H
  • Woodward 9907-018 - 2301A LOAD SHARING AND SPEED CONTROL REV.H
  • Woodward 8256-021 - EPG Rotary Actuator Model 524
  • Woodward 8446-1048 - EASYGEN RP-3000 ANNUNCIATOR REV:H HMI
  • Woodward 5501-471C - NetCon SIO Module Rev A
  • Woodward 8273-140 - 2301D LOAD SHARING AND SPEED CONTROL UNIT REV.A
  • Woodward 9905-211 - 701 DIGITAL SPEED CONTROL REV.J
  • Woodward 8272 64 - Motorized Potentiometer (MOP)
  • Woodward 9907-173 - Load Sharing Module 120V
  • Woodward 9905-797 - Digital Syncronizer
  • Woodward 8272-685 Rev L - Digital Reference Unit BRAND NEW IN BOX-
  • Woodward 8444-1081 - UMT1 Control Module 2751) [ ]
  • Woodward 9906-226 - 721 Digital Control 18W NEW LISTING
  • Woodward 8272-518 - Motor Control 110VDC Input Woodward P/N 8272 518
  • Woodward 8521-367 - UG-8 Governor P/N R R.P.M 750-1280 / UG8
  • Woodward 9907-019 Rev New 9703 - Low Voltage 2301A Load Sharing & Speed Control
  • Woodward 2001-12E2U1B1S1A 2000-4505 - FUEL SHUTOFF STOP SOLENOID VALVE
  • Woodward Easygen-2500-5 - GENSET CONTROLLER - FOR PART
  • Woodward 2001-12E2U1B1S1A 2000-4505 - FUEL SHUTOFF STOP SOLENOID VALVE
  • Woodward 9907-018 - 2301A speed control board
  • Group 8272-583 - Apm Motor Control DC24V
  • Woodward 8272-583 - Amp Motor Control DC24V
  • Woodward DPG-2201-002 - Digital Controller Revision New
  • Woodward 8440-1884K REV,K - GENERATOR CONTROLLER EASYGEN-2500-5
  • Woodward 8272-824 REV.C - LVDT SIGNAL CONDITIONER
  • Woodward 8272-582 - APM Motor Control
  • Woodward 9907-838 - LOAD SHARING MODULE REV. NEW
  • Woodward SA-4478 - EPS1000 Speed Switch
  • Woodward z 21 - governor motor rpm 1350
  • Woodward 5418-151 - Computer Assy : for Woodward 8273-256 Atlas Controller
  • Woodward 8272-517 - Pm Electric Motor
  • Woodward 5448-914 - GCP-20 Genset Controller GCP-20 REV D P/N:
  • Woodward 8440-1884 Rev J E231544 - Easy Gen 2000 Genset Controller
  • Woodward 5501-471 REV B - NETCON 5000B SIO W/SCREW POSTS
  • Woodward 8440-2512 REV B - LS-5 CIRCUIT BREAKER CONTROL PROTECTION LS-511-5/P1
  • Woodward 5466-256J REV F - Discrete I/O Module PCB
  • Woodward 8290-048 Rev. F - Generator Load Sensor 8290048
  • Woodward 9906-619 REV A - 723 PLUS DIGITAL CONTROL
  • Woodward 8440-1832 - GCP-31 NATIONAL OILWELL VARCO
  • Woodward 5466-031 REV H - NETCON IO CONTROLLER
  • Woodward ProTech 203 - Overspeed Protection System, For Parts/Repair
  • Woodward 8404-1006 - Control Module
  • Woodward 8444-1002 REV G - UMT1 MEASURING TRANSDUCERS
  • Woodward 8440-2151 REV:A - LS-522-5/P1 HMI DISPLAY [BRAND NEW ]
  • Woodward 8270-274k - Pamp Generator
  • Woodward 9907-028 REV E - SPM-A SYNCHRONIZER MODULE
  • Woodward XRW1-47 / XRW147 - 1pc XRW147 XRW1-47
  • Woodward 8440-2050 J REV - EASYGEN-3200-5 GENSET CONTROLLER (TESTED FAST SHIP)
  • Woodward 8406-011 REV.AC - GEN PART 6000 24V DC CONTROLLER - W/O ANY ACCS.
  • Woodward 8444-1019 E - Measuring Transducer WOODWARD UMT 1
  • Woodward 9907-166 Rev R - 505 Turbine Control Operator Panel New
  • Woodward 5501-471 - Actuator Driver Module, 4 Channel, (UPP)
  • Woodward 5484-875 - PM MOTOR 24VDC 5 RPM
  • Woodward 8405-062 - Actuator
  • Woodward smm40 - speed adjusting motor
  • Woodward DPG-2201-002 REV D - DIGITAL CONTROLLER NEW LISTING
  • Woodward 5484-875 - PM MOTOR 24 VDC 5 RPM
  • Woodward 5437-845 - board-notch filter 3khz
  • Woodward BL20400 - 3X400 VAC Battery Charger
  • Woodward 8800 - 1001 Rev-C - DSS-2, 2 Channel Digital Speed Switch I/N:
  • Woodward 9905-971 Rev J - Linknet 16 Channel Discrete Input Module 18-32VDC 14.2W
  • Woodward 5501-224 revC - Control Board
  • Woodward 8901-037 - Booster Servo Motor
  • Woodward 1767-367 S/N: 0920702 - Z21 WK GOVERNOR MOTOR 2700 RPM KM 58-20 K 230V
  • Woodward CSC3SUWA REV K - CSC3SUWA Controller
  • Woodward 8272-583 - APM MOTOR CONTROL
  • Woodward 5437 18 Rev.A - module netcon derivative analog
  • Woodward 5448-885 REV F - MFR1 MULTI FUNCTION RELAY
  • Woodward 8273-456 REV.A - ATLAS W/O PC104 MODULE
  • Woodward 9905-377 - 2301A Load Sharing and Speed Control
  • SAACKE F-GDSA 143303 Burner Controller for Industrial Combustion and Boiler Control Systems
  • GE ENERGY HYDRAN H201Ci-1 One-Channel Controller for Online Transformer Dissolved Gas Monitoring Systems
  • ABB 3BSE006503R1 PFSA140 Power Supply Unit for Stressometer and Industrial Automation Control Systems
  • ABB PFSC230 Cable Set 25m for DTU Connection Unit and Stressometer Flatness Measurement Systems
  • ABB NINT-73C 64513605 Main Circuit Interface Kit for ACS600 Multidrive and Industrial Drive Control Systems
  • ABB PFSA240 Roll DC Supply Unit 3BSE073476R1 Industrial Stressometer Power Supply Module for Rolling Mill Systems
  • ABB PFSA107-Z42 DTU Stressometer Digital Transmission Unit High Precision Strip Tension Measurement Module
  • GE AT868-2-1-1 Ultrasonic Flow Transmitter AquaTrans AT868 Dual Channel Industrial Flow Meter