K-WANG
- Telephone:+86-15305925923
- contacts:Mr.Wang
- Email:wang@kongjiangauto.com
Extreme situations
Terminal blocks suitable for extreme environmental conditions without XC version markings.
Figure 3 (see part number 1SAP3... (label)) is used to identify the XC version.
ABB TB511-ARCNET Terminal base
Extreme situations
Terminal blocks suitable for extreme environmental conditions without XC version markings.
Figure 3 (see part number 1SAP3... (label)) is used to identify the XC version.
Tips!
Not using wall mounted accessories will damage the module!
During screw assembly, using wall fittings (TA526) can prevent module bending and damage.
The wall fitting TA526 must be inserted.
1. Similar to a DIN rail, fasten TA526 into the rear of the module. A TA526 rotates 180 degrees.
2. Use screws (M4, maximum torque of 1.2 Nm) to tighten the module from the front end.
1. I/O bus
2 processor module slots
3 communication module slots
4 fieldbus plug interface, not suitable for terminal block TB523-2ETH
5 Power Supply 24 VDC
6 serial interface COM1
7 Network interface: TB5xx ETH: Ethernet, TB5xx-ARCNET： ARCNET
8 TB5x1: Serial interface COM2, TB5x3-2ETH: Second Ethernet network interface
9 wall mounted holes
1.5.1 Power Supply
Pin allocation label function description
The terminal board has been removed and inserted
L++24 V DC power supply voltage positive pin
L++24 V DC power supply voltage positive pin
M 0 V power supply voltage negative pin
M 0 V power supply voltage negative pin
FE functional grounding
1.5.2 Serial Interface COM1
pin assignment
Pin Pin
signal
Interface
explain
Terminal P
RS-485
Terminal P
two
RxD/TxD-P
RS-485
Receive/send, positive pole
three
three
，WOO
WO0
four
RxD/TxD-N
RS-485
Receive/send, negative pole
five
four
Terminal N
RS-485
Terminal N
six
five
RTS
RS-232
Request to send (output)
six
TxD
RS-232
Send data (output)
nine
seven
SGND
Signal grounding
Signal grounding
The terminal board has been removed
The terminal board has been inserted
RS-232
enter
eight
RxD
Receive data (input)
nine
CTS
RS-232
Clear send (input)
Tips!
Idle connector!
Ensure that the terminal board is always connected to the terminal block, even if the interface is not in use.
1.5.3 Serial Interface COM2
pin assignment
serial interface
Pin Pin
signal
Interface
explain
one
FE
Functional grounding
two
TxD
RS-232
send data
output
three
RxD/TxD-P
RS-485
Receive/Send
positive electrode
RTS
RS-232
Request to send
output
five
SGND
Signal grounding
0V power supply output
six
+5V
5V power supply output
seven
RxD
RS-232
receive data
input
eight
RxD/TxD-N
RS-485
Receive/Send
negative pole
nine
CTS
RS-232
Clear send
input
shield
FE
Functional grounding
Tips!
There is a risk of corrosion!
If XC equipment is used in a salt spray environment, idle connectors and slots may be corroded.
For XC device TA535, idle connectors and slots should be protected with TA535 protective covers.
| User name | Member Level | Quantity | Specification | Purchase Date |
|---|
-
Eckardt SRI986 Intelligent Valve Positioner -
Honeywell System 57 5704 Control System -
Schneider Electric 140CHS 1100 Communication Module -
Moog CD series compact dynamic brushless servo motor -
HARTING DIN 41612 connector -
ABB DAPU100 3ASC25H204 Interface Template -
ProSoft Technology ILX56-PBM PROFIBUS DPV1 Master/Slave Module -
Emerson DeltaV S Series Traditional I/O Modules -
MOTOROLA MVME6100 series VME single board computer -
Emerson MVME5100 Series VME Bus Processor Module -
Siemens 6EP1334-3BA00 (SITOP PSU200M) stabilized power supply -
GE Power Management SR489 Generator Management Relay -
Eaton MTLx544-S Series (MTL4544/S, MTL5544/S) Relay Power Supply -
Emerson MVME5100 Series VME Bus Processor Module -
Teknic SSt-6000-U Digital Servo Drive -
HIMA HIMatrix MI 24 01 Safety Related Controller Module -
Horner Automation MAN0344-03 Industrial Controller/Human Machine Interface (HMI) -
Emerson Automation Series MC-PHAI01 (51403479-150) 8-Channel Analog Input Module -
Bently Nevada 3500/42M Proximity Seismic Monitor -
GE VMIACC5595 Embedded Industrial Control Module -
Rockwell SLC ™ 500 series 1747-L543 (SLC 5/04 controller) -
Honeywell WEB-HMI10/CF 10.1 "TFT ARM Cortex-A53 Quad Core 3 Ethernet, 2 USB ports -
Rockwell Automation 1756 Series ControlNet Communication Module -
NI 6030E/6031E/6032E/6033E series -
ABB 1TGE120011R1000 motor and feeder control unit -
Watlow CLS200 series controller -
Schneider 140DDI84100 Discrete Input Module -
Modicon Quantum 140ACI03000 Analog Input Module -
Rockwell Automation ControlLogix 5570 and 5560 controllers -
ABB IEMMU21 module -
Endress+Hauser Prosonic T FMU30 Ultrasonic Liquid Level Measuring Instrument -
ABB SC510 submodule carrier (without CPU) -
Beijer Mitsubishi Electric E1000 Series Operation Panel -
HIMA HIMatrix F30 Compact Safety Controller -
HIMA HIMax Safety Control System -
HIMA HIMatrix F2 DO 8 01 Remote I/O Module -
HIMA HIQuad X Safety System -
HIMA HIMax X-SB 01 System Bus Module -
KOLLMORGEN Saia PCD Series I/O Modules -
Kollmorgen S700 series digital servo amplifier -
KOLLMORGEN P70360 High Performance Microstep Driver -
KOLLMORGEN AKM series synchronous servo motor -
KOLLMORGEN AKD ®- N servo drive -
AKD ® Servo driver CANopen communication -
AKD ® Servo drive fault card -
SERVOSTAR ® CD series servo amplifier -
SERVOSTAR ® CD-LITE servo amplifier -
SERVOSTAR ™ 601... 620 digital servo amplifier (S600 series) -
B&R Power Panel 300/400 Touch Screen -
Emerson S-series Mass Connection Solutions -
Emerson DeltaV SIS Logic Solver (SLS1508) -
Emerson DeltaV Ethernet I/O Card (EIOC) -
Emerson DeltaV ™ M-series Traditional I/O -
Emerson DeltaV ™ Electronic Marshalling for Migrations -
Emerson DeltaV Controller -
Emerson DeltaV Bulk Power Supplies -
Emerson DeltaV SD Plus Controller -
Emerson DeltaV M Series Virtual I/O Module 2 (VIM2) -
Emerson DeltaV M Series MD Plus Controller -
Emerson Ovation ™ Power system (5X00785G09) -
Emerson DeltaV Intelligent Switch -
Emerson A6110 Dual Channel Shaft Vibration Monitor -
Emerson MMS 3210 Dual Channel Axial Displacement Transmitter -
Emerson MMS 3120 Dual Channel Bearing Vibration Transmitter -
Emerson MMS 677X Dual Channel Bar Chart Indicator -
Emerson Martens Standard Signal Instrument S 1010 -
Emerson CON021 Eddy Current Signal Converter -
AMS 6500 Classic System Protection Card -
Emerson Machine Monitoring Systems RPM Transformer PR 9376 -
Emerson Linear Displacement Sensor PR 9350/.. Series -
Emerson PR 9376 series eddy current sensor system -
Emerson Electric Power Absolute Vibration Sensor (PR 9266/.. And PR 9268/..) -
Emerson Motion Control FX 490 -
Emerson The Ovation ™ Control System -
Emerson Ovation Distributed Control System Input/Output (I/O) Module -
Emerson HART High Performance Analog Input Module -
Emerson Ovation ™ Controller Model OCR1100 -
Emerson PAC8000 Remote I/O -
Emerson A6500-LC LVDT preamplifier -
EMERSON A6370 Overspeed Protection Monitor -
EMERSON A6110 axis relative vibration monitor -
EMERSON FloBoss ™ S600+ Flow Computer -
EMERSON CSI 2130 Machinery Health ™ Analyzer -
AMS 2140 Machinery Health ™ Analyzer -
Emerson AMS Suite: Machinery Health ™ Manager v5.61 Software Installation Guide -
GE Fanuc Series 90-30 Programmable Controller -
GE PACSystems RX7i Controller -
GE Series 90–70 Genius Bus Controller -
GE VersaMax ® Programmable controller -
GE VMIVME-7696 Pentium II processor based on VMEbus single board computer -
GE VMIVME-7695 Single Slot Pentium II Embedded Module Processor -
GE VMIVME-7459 Single Slot VME IDE CD-RW/Hard Disk Module -
GE VMIVME-6016 VMEbus Intelligent 16 Channel Asynchronous Serial Controller -
GE VMIVME-5620 Intelligent HSD Simulator -
GE VMIVME-5588 high-speed reflective memory board -
GE VMIVME-5532L VMEbus fiber optic repeater link -
GE VMIVME-5531L VMEbus fiber optic repeater link -
GE VMIVME-4514A 16 channel scanning analog I/O board -
GE VMIVME-4150 isolated 12 channel 12 bit analog output board -
GE VMIVME-3126 High Resolution Isolated Analog to Digital Converter Board -
GE VMIVME-3100 16 channel 12 bit analog-to-digital converter board -
GE VMIVME-2540 24-Channel Intelligent Counter/Controller -
GE VMIVME-2511 Programmable I/O Board -
GE VMIVME-2510B 64 bit TTL digital I/O board -
GE VMIVME-2128 128 bit high voltage digital output board -
GE VMIMPC-5790 PMC Dual Channel Ultra160 SCSI Host Adapter -
GE VMIVME-2170A 32-bit optically isolated digital output board -
GE VMIPCI-5565 Ultrahigh Speed Fiber-Optic Reflective Memory with Interrupts -
GE VMIACC-5595 2 Gb/s Reflective Memory Hub Component -
GE VME-3125A Isolation Scan 12 Bit 32 Channel Analog to Digital Converter Board (6U) -
GE VME-3122A High Performance 16 Bit Analog to Digital Converter (ADC) -
GE VMIVME-2536 32 channel optically coupled digital I/O board -
GE VMIVME-2528 128 bit TTL digital I/O TURBOModule ™ -
GE VMIVME-2232 32 32 channel relay output board -
GE VMIVME-2210 64 channel latch or momentary relay board -
GE VMIVME-1182 64 channel isolated digital input board -
GE VMIVME-1128 128 bit high-voltage digital input board -
GE VMIVME-111 64 bit High Voltage Digital Input Board -
GE ACC-0603RC V7865 VME Rear Conversion Module -
GE V7865 Intel ® Core ™ Duo Processor VME Single Board Computer -
GE MVME5500 series VME single board computer -
GE CPCI-7055RC PowerPC ® CompactPCI ® single board computer -
GE VMIVME-3125 Analog Input Board -
GE VMIVME-4105 8-Channel 12 Bit Multiplicative Digital to Analog Converter Board -
GE VMIVME-5565 Ultra High Speed Fiber Reflective Memory (with Interrupt Function) -
GE VMIVME-3122 High Performance 16 Bit Analog to Digital Converter (ADC) -
GE VMIVME-2210 Relay Board -
GE VMIVME-7648 Single Board Computer
